公司新聞
水泥穩定碎石的適用范圍與使用注意事項
來源：http://gaohufs.com/ 日期：2022-07-29
在經過粉碎的或原來松散的土中，摻入足量的水泥和水，經拌和得到的混合料在壓實和養生后，達到抗壓強度，稱為水泥穩定碎石。關于水泥穩定碎石的適用范圍與使用注意事項小編下文介紹。
After crushing or the original loose soil, add enough cement and water, and the mixture obtained by mixing will reach the compressive strength after compaction and curing, which is called cement stabilized crushed stone. The application scope and precautions of cement stabilized macadam are introduced below.
水泥穩定碎石的適用范圍
Application scope of cement stabilized macadam
水泥穩定碎石可適用于各級公路的基層和底基層，但水泥土不得用做二級和二級以上公路高級路面的基層。水泥穩定中粒土和粗粒土用做基層時，水泥穩定碎石的水泥劑量一般在3%左右，不超過6%。必要時，應首先改善集料的級配，然后用水泥穩定。
Cement stabilized macadam can be applied to the base and subbase of highways at all levels, but cement soil cannot be used as the base of high-grade pavement of secondary and above highways. When cement stabilized medium grained soil and coarse grained soil are used as base course, the cement dosage of cement stabilized crushed stone is generally about 3%, not more than 6%. If necessary, the gradation of aggregate should be improved first, and then stabilized with cement.
在只能使用水泥穩定細粒土做基層時或水泥穩定集料的強度要求明顯大于規定時，水泥劑量不受此限制。
When only cement stabilized fine-grained soil can be used as the base or the strength requirements of cement stabilized aggregate are significantly greater than the regulations, the cement dosage is not subject to this restriction.
水泥穩定碎石的使用注意事項
Precautions for the use of cement stabilized macadam
1、濟南水泥穩定碎石用做底基層時，單個顆粒的大粒徑不應超過375mm水泥穩定碎石的顆粒組成應在級配范圍內，土的均勻系數應大于5細粒土的液限不應超過40%，塑性指數不應超過17對于中粒土和粗粒土，如土中小于06mm的顆粒含量在30%以下，塑性指數可稍大。
1. When Jinan cement stabilized macadam is used as subbase, the large particle size of a single particle should not exceed 375mm, the particle composition of cement stabilized macadam should be within the grading range, the uniformity coefficient of soil should be greater than 5, the liquid limit of fine-grained soil should not exceed 40%, and the plasticity index should not exceed 17. For medium-grained soil and coarse-grained soil, if the content of particles less than 06mm in soil is less than 30%, the plasticity index can be slightly larger.
實際工作中，宜選用均勻系數大于10、塑性指數小于12的土。塑性指數大于17的土，宜采用石灰穩定，或用水泥和石灰綜合穩定。對于中粒土和粗粒土，宜采用表322中2號級配，但小于0075mm的顆粒含量和塑性指數可不受限制。
In practical work, the soil with uniformity coefficient greater than 10 and plasticity index less than 12 should be selected. The soil with plasticity index greater than 17 should be stabilized with lime or cement and lime. For medium grained soil and coarse grained soil, the No. 2 grading in table 322 should be adopted, but the particle content and plasticity index less than 0075mm can be unlimited.
2、水泥穩定碎石用做基層時，單個顆粒的大粒徑不應超過315mm水泥穩定碎石的顆粒組成應在級配范圍內。
2. When cement stabilized macadam is used as base course, the large particle size of a single particle shall not exceed 315mm, and the particle composition of cement stabilized macadam shall be within the grading range.
3、水泥穩定碎石用做基層時，對所用的碎石或礫石，應預先篩分成3~4個不同粒級，然后配合，使顆粒組成符合表322所列級配范圍。
3. When cement stabilized crushed stone is used as base course, the crushed stone or gravel used shall be screened into 3-4 different particle grades in advance, and then mixed to make the particle composition conform to the grading range listed in table 322.
以上是小編介紹的水泥穩定碎石的適用范圍與使用注意事項，希望對您有所幫助。了解更多相關的知識，歡迎繼續關注我們的網站http://gaohufs.com。
The above is the scope of application and precautions of cement stabilized macadam introduced by the editor. I hope it will be helpful to you. For more relevant knowledge, please continue to pay attention to our website http://gaohufs.com 。
公司地址：濟南市商河縣賈莊鎮民營經濟創業園
公司名稱:永誠廣建公路材料（山東）有限公司 
備案號：